- #2000 AUDI A4 STEREO REMOVAL WITHOUT STEREO TOOLS INSTALL#
- #2000 AUDI A4 STEREO REMOVAL WITHOUT STEREO TOOLS MANUAL#
Once out of the car the fuel supply line will be easier to remove from the fuel tank cover. The fuel pump can be removed with the fuel tank cover still attached via the wires and fuel supply line. The fuel supply line is difficult to remove (one-time-use connectors hold the line onto both the pump and tank cover).
The fuel pump electrical connections and fuel supply line are also connected to the underside of the fuel tank cover.
This is for the fuel tank level sending unit. There is a green and black connector on the underside of the fuel tank cover. Gently pry the fuel tank cover up to reveal the fuel pump and inner fuel tank This will relieve pressure on the seal and allow the cover to come off. Now that the fuel lines and electrical connections are disconnected use the flat blade screwdriver and dead blow hammer to rotate the fuel tank cover trim ring counter-clockwise (to the left). Be gentle for these fuel lines (like the ones on the fuel filter) can be brittle. This, in turn, releases the lock on the tab within the fuel tank cover. The key is to push the round side (opposite of the flat side) inward and pull up on the chassis fuel line. A pair of needle-nosed pliers works well. Note the various connections on the top of the fuel tank: The Trim Ring that locks and seals the top down onto the fuel tank, Fuel supply line and fuel return lines (fuel filter acts as the fuel pressure regulator) and Electrical connections.ĭisconnect the electrical connections and move them aside. The finished result will look something like what is pictured to the left.: Use paper towels to soak up the excess Brake Clean and dirt. Carefully spray the top of the fuel pump location with Brake Clean to remove the dirt. It is recommended to clean this dirt off, to the best of one’s ability, otherwise it will fall into the fuel tank while removing the fuel pump. If the vehicle has some mileage on it the top of the fuel tank will be fairly dirty. It also seals off the interior of the vehicle from the underside of the chassis. This cover provides access to the top of the fuel tank through the chassis. The cover can then be removed with gentle force. Remove all three screws with a Phillips screwdriver. The cover on the passenger side houses the fuel pump and fuel level sending unit and is pictured ot the right. Below on the left you will see the driver's side electrical seat connections, and on the right are the passenger side connectionsĪfter everything is disconnected, remove the rear seatĪfter you remove the seat you will see two covers on either side of the chassis. Once the seat is released from the car chassis disconnect the seatbelt wires and heated seat wires (if equipped) at the connectors. You have to pull up on the front side of the seat to unseat the clips from the body. The rear seat cushion is held in with two clips in the front of the seat on either side of the cushion.
On Quattro equipped vehicles, the fuel pump is located underneath the rear seat. To the right is a picture of the stock fuel pump (right) next to the new high-output fuel pump with hardware kit (left). The 034 High-Output Fuel pump kit comes with the pump, a new rubber fuel line, new electrical connections, hose clamps and other associated hadware needed for the install. This job should also be performed in a well ventilated area and away from any source of open flames. It is recommended to perform this job with a fuel tank level less than or equal to 1/4 full.
#2000 AUDI A4 STEREO REMOVAL WITHOUT STEREO TOOLS MANUAL#
Consult Bentley Service Manual for FWD models. Front-Wheel-Drive (FWD) may be different in regards to location of the fuel pump within the chassis. It should also be noted that this DIY is specific to Quattro equipped vehicles. This DIY could also be used for removal and installation of an OEM fuel pump if so desired. This DIY covers replacement of the OEM fuel pump with the 034 High-Output B6 Fuel Pump (with 040 option) from Deutsch Teile Haus. Engine Coolant Temp Sensor (G62) Replacement.
#2000 AUDI A4 STEREO REMOVAL WITHOUT STEREO TOOLS INSTALL#
0 kommentar(er)
